Total time: 18 hour – Prep time: 10 hours – Cook time: 8 hour
Look for around an 8 to 10 pound bone-in butt or shoulder roast. You will want to start the recipe the day before you smoke the meat by marinating it in mustard, sugar, salt, spices, and herbs. The sugar and salt will act almost as a dry brine. This combination will pull some of the excess moisture out. This is good so that the meat really smokes and doesn’t steam. The day of smoking will be an 8 to 10 hour project that really doesn’t require that much effort on your part. You will just need to tend to the smoker and/or roast about every 60 minutes. Plan on doing some yard work, reading a good book, watching the game, making side dishes, or chilling in your hot tub while the smoker does most of the hard work for you. It is worth a day spent at home for the results achieved.
This recipe will serve approximately 10 to 16 people, depending on appetites. Preparation time is approximately 20 minutes for a bone-in roast. Cook time is approximately 8 to 10 hours. This recipe yields sweeter smoked pork, but the apple cider vinegar spritz will. help to mellow that a bit.
• Masterbuilt Digital Electric smoker or any smoker that will handle this size roast
• Paper towels
• Cutting board
• Sharp chef’s knife
• Disposable foil roasting pan large enough to hold the meat (or 2)
• Plastic wrap or aluminum foil
• Meat thermometer
• Hickory or apple wood chips
• A spray bottle
• 2 large forks
Ingredients for the dry rub (or you may use your own dry rub)
• 8 pound bone-in Boston butt roast
• 5 TBS jarred yellow mustard
• 1/3 cup packed brown sugar
• 3 TBS sea salt
• 2 TBS paprika
• 1 TBS garlic powder
• 1 TBS onion powder
• 2 tsps cracked black pepper
• 1/2 tsp cayenne pepper
1. Place the roast on a clean cutting board. If your roast has skin and/or a fat cap, trim most of the fat off, leaving a 1/4 inch layer for extra flavor. After trimming the fat, rinse the roast under cold running water and pat completely dry with plenty of paper towels. Place the roast inside the disposable pan.
2. Combine the dry rub ingredients in a bowl.
3. Time to get your hands dirty (or wear disposable gloves). Rub the entire roast well with the mustard to coat. Generously apply the dry rub, pressing it into the mustard, to completely cover the butt. The mustard will help to hold the dry rub in place.
4. Cover the pan tightly with plastic wrap or aluminum foil. Place the pan in the refrigerator for 8 to 12 hours, basically overnight – any more than 24 hours is too long, as it will draw too much moisture out of the meat.
5. An hour before you fire up the smoker, remove the roast from the refrigerator so that it can come to almost room temperature. After it has rested for an hour, remove the wrap and pour off any of the accumulated liquid in the bottom of the pan.
6. Add the hickory or apple wood chips to the smoker drawer. Fill the water pan half way. Preheat the smoker to 225 degrees F.
7. Place the roast on the upper rack of the smoker. Thoroughly wash out the disposable pan and place it on the rack below the roast to catch any drippings. Alternatively, use a clean disposable pan, if you have one. If your smoker has a meat thermometer attached, insert it into the roast at one end.
8. While the pork is smoking, make a side of coleslaw, pickled vegetables, or macaroni & cheese. (See suggestions below).
9. Smoke for approximately 8 hours.* Because of the sugar the meat will form a dark caramelized crust. This is delicious crunchy stuff. Replenish the wood chips and liquid approximately every 60 minutes. If you don’t see any smoke coming from the vent, it is time to replenish. If desire, at 2 hour intervals spray some apple cider vinegar on the roast just to moisten it. It is okay to turn the roast over once, but not necessary.
10. At 8 hours, check the internal temperature of the meat with a thermometer. It should read 190 degrees F or even a little higher. If it isn’t quite up to temperature remove the pan of drippings and place the butt inside the pan. Cover this with new aluminum foil and place the roast back in the smoker until it reaches the desired temperature, approximately 1 hour more. The pan and foil will help the meat to retain heat and cook thoroughly.
11. Allow the fully cooked roast to rest for at least 20 to 30 minutes until cool enough to handle and to be able to remove the bone.
12. While the pork is resting, make a BBQ sauce and cut some soft rolls to assemble pulled pork sandwiches.
13. After the pork has cooled enough to touch, place it on a clean cutting board and pull the roast using 2 forks to shred the meat into strands.
14. Place the pulled pork (and juices if desired) in a large serving bowl or platter with some tongs for everyone to help themselves. You might want to remove some of the fat from the juices using a fat separator before adding to the pork.
*If using a charcoal smoker, rotate the meat every hour for more even cooking.
- News (38)
- May 2020
- April 2020
- March 2020
- February 2020
- January 2020
- December 2019
- September 2019
- June 2019
- February 2019
- November 2018
- September 2018
- August 2018
- March 2018
- February 2018
- January 2018
- December 2017
- October 2017
- September 2016
- July 2016
- February 2016
- September 2015
- April 2015
- February 2015
- January 2015